Wood you? Novel pigment tipped for gummy and hard candies

By Annie Harrison-Dunn contact

- Last updated on GMT

The pigment neocandenatone could be of interest to consumers due to evidence of possible antioxidant activity and in vitro cytotoxic activity against HeLa cervical cancer cells, researchers say.
The pigment neocandenatone could be of interest to consumers due to evidence of possible antioxidant activity and in vitro cytotoxic activity against HeLa cervical cancer cells, researchers say.
Neocandenatone, a purple pigment found in the heartwood of Dalbergia congestiflora trees, could hold colorant possibilities for gummy and hard candies, according to Mexican research.

According to the study published in the journal Food Research International, ​neocandenatone showed “excellent integration and stability”​ in matrices for both gelatin gummies and hard candies.

The researchers looked at three neocandenatone samples of different purities, analyzing the genotoxicity using Ames and micronucleus tests – the first of which they said was favored by the US Food and Drug Administration (FDA). The pigment was applied to 11 gelatin gummy and ten hard candy formulations to establish its stability during storage compared to candies colored with commercial anthocyanin (E number 163) from various sources including black carrot, grape skin, purple corn, elderberry, and strawberry.

They said the pigment could be of interest to consumers due to evidence of possible antioxidant activity and in vitro​ cytotoxic activity against HeLa cervical cancer cells.

A hearty color

The researchers said the Mexican tree was known for its deeply pigmented heartwoods of varying colors, often used for wooden crafts, instruments and in traditional medicine. Heartwood refers to the older wood at the center of a tree, which is usually darker and harder than younger sapwood.

Pigment was extracted from dried and ground D. congestiflora​ heartwood using methanol.

The researchers found that: “The neocandenatone content in the wood was higher than the 2.41% and 1.37% anthocyanin content (dry matter) found in the grape skin Sousón cultivar and skins of​ Vaccinium ashei​ var. climax fruits, respectively.”

Gummy color gradient

candy pigment
Pigmented products with neocandenatone (N) and with anthocyanins (A) in gelatin gummies (G) and hard candies (C). 

Different shades were obtained depending on the concentration of pigment and the amount of citric acid used, with neocandenatone and enocyanin (a type of anthocyanin) producing similar colors with and without acid. In the gummy formulations neocandenatone provided a wider range of colors compared to the anthocyanins.

In the gummies a purple color was obtained with 0.014% pigment and 0.0% citric acid, red with 0.014% pigment and 1.0% citric acid. The researchers said smaller amounts of neocandenatone than enocyanin produced similar colorations, while a purple color in end product gummies not just solution was not possible with enocyanin. 

Hard to crack

Anthocyanin and neocandenatone gave an equally broad range of colors in the hard candy final products. However, anthocyanin coloration varied with pH and the presence of citric acid, making it sometimes impossible to establish a correlation between acid concentration and color parameter values and therefore difficult to compare. 

“In this work, it was clear that the range of colors in the candy products depended heavily on the candy matrix,”​ the researchers said. 

“As expected, the colorations in hard candies depended on the pigment and acid concentrations. In contrast to gummies, similar neocandenatone and enocyanin concentrations must be used to achieve similar colorations in hard candies. It was not possible to obtain purple color in hard candies using any of the tested formulations.”

Crude vs. pure

The crude extract of D. congestiflora ​was composed of approximately 93% hydrophobic compounds, which restricted its dispersion in aqueous matrices like candy products. The researchers recommended the use of a semi-purified extract containing 71% neocandenatone since pure pigment via chromatographically was “very expensive”​.  However, the researchers said the crude extract could be used in fatty matrices where it could be dispersed. 

 

Source: Food Research International

Available online ahead of print, doi: 10.1016/j.foodres.2014.03.048

“Stability in candy products of neocandenatone, a non-genotoxic purple pigment from Dalbergia congestiflora heartwood”

Authors: C. G. Gutiérrez-Zúñiga, M. Arriaga-Alba, C. Ordaz-Pichardo, P. Gutiérrez-Macías, B. E. Barragán-Huerta

Related topics: R&D, Confectionery, Flavors and colors

Related news

Related products

show more

Dupont

Naturally-Derived Carrier and Extraction Solvent

DuPont Tate & Lyle Bio Products | 17-Oct-2017 | Technical / White Paper

Zemea® USP-FCC enables flavorists to use an alternative to petroleum-based carriers and solvents that is naturally-derived, environmentally sustainable,...

OLAM SVI-Spices-610x343

Olam SVI Spices MarketReport Apr ’17

Olam SVI | 11-Oct-2017 | Data Sheet

Olam SVI's experts regularly publish supply chain forecasts and critical market intelligence to help its customers. The April 2017 Olam SVI Spices...

High Pressure Processing  - HPP

High Pressure Processing - HPP

Accurate filing of high value FMCG in glass jars | 22-Sep-2017 | Technical / White Paper

HPP offers opportunities for product innovation and extended shelf life. HPP is a proven all-natural technique that preserves the vitamins, taste and texture...

Related suppliers

Follow us

Featured Events

View more

Products

View more

Webinars